Golf carts manufactured by E-Z-Go have an extensive range of body styles and are customizable to serve various functions. One thing that is pretty consistent among all E-Z-Go golf carts is that they are all powered by batteries.
EZ Go Gas Golf Cart Battery requires you to use lead acid flooded batteries. These kinds of batteries are appropriate for Gas run golf carts. These batteries give you plenty of room to spare so your golf cart can stay out on the game for longer.
The 55-minute backup time at 75-amp current output of this battery is impressive. Stay with us throughout the whole article to know how to replace the EZ Go gas golf cart batteries and how to take good care of them for long-term use.
Battery Setup On Ez Go Golf Cart
E-Z-Go golf carts have a two-bank system for their 36-volt battery system, and the system is wired in series.
It is absolutely essential that you correctly connect the batteries to the E-Z-Go golf cart in order to ensure that it functions as expected.
This allows your golf cart to make the most out of each battery. However, if the batteries are not properly connected, it can have a detrimental effect on you as well as on the cart.
This could happen due to the overheating of the battery that might explode if they are not properly connected.
Ez Go Gas Golf Cart Battery Replacement
If you are planning to change the batteries from your EZ Go Gas Golf Cart, then follow the following steps.
Since corrosion and deterioration can affect older golf carts, we’ll want to inspect the battery pack and its connections first. You should always replace worn-out cables to guarantee optimal performance.
Take Out the Worn-out Battery Pack
Then, you can start removing the dead batteries. After finishing this step, you should look for leaks and corrosion around the battery and in the frame.
If there is any battery acid left over, you must wash it off with a water hose. When you finish the cleaning, let the area dry and then coat the frame with a corrosion treatment.
With this step, you can mitigate the inevitable process of corrosion to some degree. As opposed to the Club Car’s lightweight aluminum frame, the EZGO’s steel frame is a common point of criticism.
Setting Up A Fresh and New Set of Batteries
First of all place the positive terminals of three batteries towards the front of the cart. And the rest of the terminals of the three batteries toward the rear of the cart.
Then, slide a battery wire from the right-side positive terminal to the left-side negative terminal.
After this, connect the first battery’s positive terminal to the second battery’s negative terminal in the front of the cart.
Repeat this process with the next two batteries. This opens the third battery’s positive terminal.
Similarly, connect the first battery’s negative terminal to the second battery’s positive terminal on your right on the rear of the cart.
Again, repeat this process for the next two batteries. And then, the third battery’s negative terminal will open.
Finally, slide the golf cart’s positive battery cable onto the third battery in the first bank and the negative battery cable onto the third battery in the second bank. Then, attach the battery terminal nut socket to the inch-pound torque wrench.
Apply a protective coating to each battery terminal to finish connecting the E-Z-Go golf cart batteries.
Ez Go Gas Golf Cart Battery Life and Maintenance
Sealed lead acid batteries typically have a 5-year lifespan. Maintaining your battery on a consistent basis is essential if you want to get the longest life out of it. Here are some basic tips for maintenance:
Flooded Batteries Need Water
To maintain the appropriate level of electrolyte in flooded batteries, you must occasionally add distilled water.
You should keep the electrolyte levels in your golf cart in check once a month up to once a week, depending on how frequently you use it.
Raise the water level until it is just a fraction of an inch above the battery plates. If your golf cart uses AGM or lithium batteries, there’s no need to top them off with water.
Be Sure to Charge Your Battery Properly
Choose a charger that works with the output power and chemistry of the batteries for the best results. For a cart with six 8-volt batteries, what you will need is a 48-volt charger.
Similarly, whether you’re using flooded, AGM, or lithium-ion batteries, the charger you choose must be suitable for those specific types of batteries.
Keep Your Battery Charged at All Times
The plates inside of your battery will sulfate if it is discharged to a low enough level, preventing electricity from flowing. Electric golf carts need an external charger to keep the battery charged.
If your battery life drops below 50%, you should recharge it immediately.
Do Not Overcharge
The battery’s performance will suffer if you overcharge it. You should either keep an eye on the charging process or invest in a charging station with a float configuration that turns off autonomously when the battery is fully charged.
Make Sure the Battery Terminals Are Always Clean
Use a wire brush and a solution of baking soda and water to remove any corrosion that has accumulated on the battery’s terminals. After that, you can use an anti-corrosion mist to make sure the rust doesn’t come back.
As an E-Z-Go golf cart has a two-bank and wired system battery, it can be hard to understand a few things. The answers to these frequently asked questions can be of help:
How much does a gas golf cart battery cost?
A new battery for a golf cart will cost around $800 to $1,500 on average. In order to power a high-performance golf cart like a 72V, you will need to install more expensive batteries. And this can add up to a price tag of around $2,000.
Is a car battery compatible with a battery for a gas-powered golf cart?
The answer, in a word, is yes. You could series-connect three or four 12-volt car batteries to create the necessary 36 or 48 volts for your golf cart motor. Car batteries are commonly available and are 12 volts in size.
What should I keep in mind before replacing my ez go gas golf cart battery?
You should keep in mind that an EZ Go Gas Golf Cart Battery requires you to use lead acid flooded batteries. These kinds of batteries are appropriate for Gas run golf carts.
Golf carts do not only have an extensive range of body styles but are also customizable to serve various functions. Which is why, changing the batteries of your golf cart can be a pain if you don’t know what you are doing.
But after going through this article, now you know how to change the batteries and how to take good care of them.
In this article, we have tried to cover what to do and what not to do while replacing an ez go gas golf cart battery. We hope you have found your answer in our piece. Happy riding!
- Read Also: EZGo Golf Cart Won’t Go Forward or Reverse: 6 Easy Solutions
- Read Also: Ultimate Guide On EZGO TXT Governor Adjustment
- Read Also: EZGO RXV 48 Volt Battery Wiring Diagram: An Easy Written Solution For You
- Read Also: EZGo Express S4 Upgrades | Increase Your Golf Cart’s Performance
- Read Also: Ultimate Guide on EZGo Golf Cart Suspension Upgrade
Meet Jalal, a passionate golf writer and the driving force behind Golfertroop.com, your go-to destination for all things golfing! Whether you’re a seasoned golfing veteran or a beginner taking your first swing, Jalal is here to assist you in making the most out of your golfing experience.